| Common Name: | SUMA BREAK UP II HEAVY DUTY FOAMING GREASE-RELEASE CLEANER, UNDILUTED PRODUCT |
| Manufacturer: | DIVERSEY |
| SDS Revision Date: | 4/3/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 32GP53 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DIVERSEY(TM)
SAFETY DATA SHEET
SUMA BREAK UP II HEAVY DUTY FOAMING GREASE-RELEASE CLEANER
VERSION NUMBER: 2
PREPARATION DATE: 2018-04-03
| 1. IDENTIFICATION |  |
PRODUCT NAME: SUMA BREAK UP II HEAVY DUTY FOAMING GREASE-RELEASE CLEANER
PRODUCT CODE: 95499058
SDS #: MS0801043
RECOMMENDED USE:
INDUSTRIAL/INDUSTRIAL
CLEANER/DEGREASER
THIS PRODUCT IS INTENDED TO BE DILUTED PRIOR TO USE
USES ADVISED AGAINST: USES OTHER THAN THOSE IDENTIFIED ARE NOT RECOMMENDED
MANUFACTURER, IMPORTER, SUPPLIER:
US HEADQUARTERS:
DIVERSEY, INC.
2415 CASCADE POINTE BLVD.
CHARLOTTE, NC 28208
PHONE: 1-888-352-2249
SDS INTERNET ADDRESS: HTTPS://SDS.DIVERSEY.COM
CANADIAN HEADQUARTERS:
DIVERSEY CANADA, INC.
3755 LAIRD ROAD
UNITS 8-11
MISSISSAUGA, ONTARIO L5L 0B3
PHONE: 1-800-668-7171
EMERGENCY TELEPHONE NUMBER:
1-800-851-7145
1-651-917-6133 (INT'L)
| 2. HAZARDS IDENTIFICATION | |
CLASSIFICATION FOR THE UNDILUTED PRODUCT:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
CORROSION
SIGNAL WORD: DANGER.
HAZARD AND PRECAUTIONARY STATEMENTS:
CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE DAMAGE.
CAUSES BURNS/SERIOUS DAMAGE TO MOUTH, THROAT AND STOMACH. KEEP CONTAINER
TIGHTLY CLOSED. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. WASH AFFECTED
AREAS THOROUGHLY AFTER HANDLING. WEAR CHEMICAL-SPLASH GOGGLES AND
CHEMICAL-RESISTANT GLOVES.
IF SWALLOWED:
RINSE MOUTH. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL
PERSONNEL. DRINK A CUPFUL OF MILK OR WATER.
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE OR ATTENTION.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING FOR AT LEAST 15 MINUTES.
IMMEDIATELY CALL A POISON CENTER (1-800-851-7145) OR PHYSICIAN. TAKE OFF
CONTAMINATED CLOTHING AND WASH IT BEFORE REUSE. DISPOSE OF IN ACCORDANCE
WITH ALL FEDERAL, STATE AND LOCAL APPLICABLE REGULATIONS.
SUPPLEMENTAL INFORMATION:
MIX ONLY WITH WATER. DO NOT MIX WITH ANY OTHER PRODUCT OR CHEMICAL. CAN
REACT TO RELEASE HAZARDOUS GASES. MAY VIGOROUSLY REACT WITH ACIDS RESULTING
IN SPATTERING AND EXCESSIVE HEAT.
HEALTH HAZARDS NOT OTHERWISE CLASSIFIED (HHNOC): NOT APPLICABLE
PHYSICAL HAZARDS NOT OTHERWISE CLASSIFIED (PHNOC): NOT APPLICABLE
CLASSIFICATION FOR THE DILUTED PRODUCT @ 1:9:
THIS PRODUCT, WHEN DILUTED AS STATED ON THE LABEL, IS NOT CLASSIFIED AS
HAZARDOUS ACCORDING TO OSHA 29 CFR 1910.1200 (HAZCOM 2012-GHS) AND CANADIAN
HAZARDOUS PRODUCTS REGULATIONS (HPR) (WHMIS 2015-GHS).
HAZARD AND PRECAUTIONARY STATEMENTS: NONE REQUIRED.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CLASSIFIED INGREDIENTS:
INGREDIENT(S) CAS # WEIGHT %
COCAMIDOPROPYL BETAINE 61789-40-0 3 - <5%
ALCOHOL ETHOXYLATES 68439-46-3 3 - <5%
LAURYL DIMETHYL AMINE OXIDE 1643-20-5 1 - <3%
POTASSIUM HYDROXIDE 1310-58-3 >0.1 - <1%
*EXACT PERCENTAGES ARE BEING WITHHELD AS TRADE SECRET INFORMATION
| 4. FIRST AID MEASURES | |
UNDILUTED PRODUCT:
EYES:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING FOR AT LEAST 15 MINUTES.
SKIN:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH WATER FOR
AT LEAST 15 MINUTES.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
INHALATION:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
INGESTION:
IF SWALLOWED:
RINSE MOUTH. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL
PERSONNEL. DRINK A CUPFUL OF MILK OR WATER.
MOST IMPORTANT SYMPTOMS/EFFECTS: NO INFORMATION AVAILABLE.
IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED: NOT APPLICABLE.
DILUTED PRODUCT:
EYES: RINSE WITH PLENTY OF WATER.
SKIN: NO SPECIFIC FIRST AID MEASURES ARE REQUIRED
INHALATION: NO SPECIFIC FIRST AID MEASURES ARE REQUIRED
INGESTION:
IF SWALLOWED:
CALL A POISON CENTER (1-800-851-7145) OR DOCTOR/PHYSICIAN IF YOU FEEL
UNWELL.
| 5. FIRE-FIGHTING MEASURES | |
SPECIFIC METHODS: NO SPECIAL METHODS REQUIRED
SUITABLE EXTINGUISHING MEDIA: NOT APPLICABLE.
SPECIFIC HAZARDS: CORROSIVE MATERIAL (SEE SECTIONS 8 AND 10).
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
EXTINGUISHING MEDIA WHICH MUST NOT BE USED FOR SAFETY REASONS:
NO INFORMATION AVAILABLE.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8.).
ENVIRONMENTAL PRECAUTIONS AND CLEAN-UP METHODS:
CLEAN-UP METHODS - LARGE SPILLAGE. ABSORB SPILL WITH INERT MATERIAL
(E.G. DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL WASTE CONTAINER.
USE A WATER RINSE FOR FINAL CLEAN-UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
AVOID CONTACT WITH SKIN, EYES AND CLOTHING. DO NOT TASTE OR SWALLOW. AVOID
BREATHING VAPORS OR MISTS. USE ONLY WITH ADEQUATE VENTILATION. REMOVE AND
WASH CONTAMINATED CLOTHING AND FOOTWEAR BEFORE RE-USE. WASH THOROUGHLY
AFTER HANDLING. PRODUCT RESIDUE MAY REMAIN ON/IN EMPTY CONTAINERS. ALL
PRECAUTIONS FOR HANDLING THE PRODUCT MUST BE USED IN HANDLING THE EMPTY
CONTAINER AND RESIDUE. MIX ONLY WITH WATER. DO NOT MIX WITH ANY OTHER
PRODUCT OR CHEMICAL. CAN REACT TO RELEASE HAZARDOUS GASES. MAY VIGOROUSLY
REACT WITH ACIDS RESULTING IN SPATTERING AND EXCESSIVE HEAT. FOR
COMMERCIAL AND INDUSTRIAL USE ONLY.
STORAGE:
PROTECT FROM FREEZING. KEEP TIGHTLY CLOSED IN A DRY, COOL AND
WELL-VENTILATED PLACE.
AEROSOL LEVEL (IF APPLICABLE): NOT APPLICABLE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
INGREDIENT(S) CAS # ACGIH OSHA
POTASSIUM HYDROXIDE 1310-58-3 2 MG/M3 (CEILING)
UNDILUTED PRODUCT:
ENGINEERING MEASURES TO REDUCE EXPOSURE:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL AIRBORNE LEVELS.
PERSONAL PROTECTIVE EQUIPMENT:
EYE PROTECTION: CHEMICAL-SPLASH GOGGLES.
HAND PROTECTION: CHEMICAL-RESISTANT GLOVES.
SKIN AND BODY PROTECTION:
PROTECTIVE FOOTWEAR. IF MAJOR EXPOSURE IS POSSIBLE, WEAR SUITABLE
PROTECTIVE CLOTHING AND FOOTWEAR.
RESPIRATORY PROTECTION:
NO PERSONAL PROTECTIVE EQUIPMENT REQUIRED UNDER NORMAL USE CONDITIONS.
HYGIENE MEASURES:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
DILUTED PRODUCT:
ENGINEERING MEASURES TO REDUCE EXPOSURE:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL AIRBORNE LEVELS
EYE PROTECTION:
NO PERSONAL PROTECTIVE EQUIPMENT REQUIRED UNDER NORMAL USE CONDITIONS.
HAND PROTECTION:
NO PERSONAL PROTECTIVE EQUIPMENT REQUIRED UNDER NORMAL USE CONDITIONS.
SKIN AND BODY PROTECTION:
NO PERSONAL PROTECTIVE EQUIPMENT REQUIRED UNDER NORMAL USE CONDITIONS.
RESPIRATORY PROTECTION:
NO PERSONAL PROTECTIVE EQUIPMENT REQUIRED UNDER NORMAL USE CONDITIONS.
HYGIENE MEASURES:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
COLOR: CLEAR YELLOW
EVAPORATION RATE: NO INFORMATION AVAILABLE
ODOR: SOLVENT
ODOR THRESHOLD: NO INFORMATION AVAILABLE.
BOILING POINT/RANGE: NOT DETERMINED
MELTING POINT/RANGE: NOT DETERMINED
DECOMPOSITION TEMPERATURE: NOT DETERMINED
AUTOIGNITION TEMPERATURE: NO INFORMATION AVAILABLE
SOLUBILITY: COMPLETELY SOLUBLE
SOLUBILITY IN OTHER SOLVENTS: NO INFORMATION AVAILABLE
RELATIVE DENSITY (RELATIVE TO WATER): 1.022
DENSITY:
8.52 LBS/GAL
1.022 KG/L
VAPOR DENSITY: NO INFORMATION AVAILABLE
BULK DENSITY: NO INFORMATION AVAILABLE
VAPOR PRESSURE: NO INFORMATION AVAILABLE.
FLASH POINT (DEG. F):
>200 DEG. F
>93.4 DEG. C
PARTITION COEFFICIENT (N-OCTANOL/WATER): NO INFORMATION AVAILABLE
VISCOSITY: NO INFORMATION AVAILABLE
ELEMENTAL PHOSPHORUS: 0.00% BY WT.
VOC: 0% *
PH: 13.4
FLAMMABILITY (SOLID OR GAS): NOT APPLICABLE
CORROSION TO METALS: NOT CORROSIVE
SUSTAINED COMBUSTION: NOT APPLICABLE
EXPLOSION LIMITS:
UPPER: NOT DETERMINED
LOWER: NOT DETERMINED
@ 1:9 12.4:
>200 DEG. F
>93.4 DEG. C
VOC % BY WT. AT USE DILUTION: 0
* - TITLE 17, CALIFORNIA CODE OF REGULATIONS, DIVISION 3, CHAPTER 1,
SUBCHAPTER 8.5, ARTICLE 2, CONSUMER PRODUCTS, SECTIONS 94508
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NOT APPLICABLE
STABILITY: THE PRODUCT IS STABLE
POSSIBILITY OF HAZARDOUS REACTIONS:
MAY VIGOROUSLY REACT WITH ACIDS RESULTING IN SPATTERING AND EXCESSIVE HEAT.
HAZARDOUS DECOMPOSITION PRODUCTS: NONE REASONABLY FORESEEABLE.
MATERIALS TO AVOID:
STRONG ACIDS. DO NOT MIX WITH ANY OTHER PRODUCT OR CHEMICAL UNLESS
SPECIFIED IN THE USE DIRECTIONS.
CONDITIONS TO AVOID: NO INFORMATION AVAILABLE.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
SKIN CONTACT, INHALATION, INGESTION, EYE CONTACT
DELAYED, IMMEDIATE, OR CHRONIC EFFECTS AND SYMPTOMS FROM SHORT AND
LONG-TERM EXPOSURE:
SKIN CONTACT:
CAUSES SKIN IRRITATION. SYMPTOMS MAY INCLUDE PAIN (WHICH MAY BE DELAYED),
REDNESS, AND/OR DISCOMFORT.
EYE CONTACT:
CORROSIVE. CAUSES SERIOUS EYE DAMAGE. SYMPTOMS MAY INCLUDE PAIN, BURNING
SENSATION, REDNESS, WATERING, BLURRED VISION OR LOSS OF VISION.
INGESTION:
CAUSES BURNS/SERIOUS DAMAGE TO MOUTH, THROAT AND STOMACH. SYMPTOMS MAY
INCLUDE STOMACH PAIN AND NAUSEA.
INHALATION:
MAY CAUSE IRRITATION AND CORROSIVE EFFECTS TO NOSE, THROAT AND RESPIRATORY
TRACT. SYMPTOMS MAY INCLUDE COUGHING AND DIFFICULTY BREATHING.
SENSITIZATION: NO KNOWN EFFECTS.
TARGET ORGANS (SE): NONE KNOWN
TARGET ORGANS (RE): NONE KNOWN
NUMERICAL MEASURES OF TOXICITY:
ATE - ORAL (MG/KG): >5000
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: NO INFORMATION AVAILABLE.
PERSISTENCE AND DEGRADABILITY: NO INFORMATION AVAILABLE.
BIOACCUMULATION: NO INFORMATION AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
WASTE FROM RESIDUES / UNUSED PRODUCTS (UNDILUTED PRODUCT):
THIS PRODUCT, AS SOLD, IF DISCARDED OR DISPOSED, IS A HAZARDOUS WASTE
ACCORDING TO FEDERAL REGULATIONS (40 CFR 261.4 (B)(4)). UNDER RCRA, IT IS
THE RESPONSIBILITY OF THE USER OF THE PRODUCT TO DETERMINE, AT THE TIME
OF DISPOSAL, WHETHER THE WASTE SOLUTION MEETS RCRA CRITERIA FOR HAZARDOUS
WASTE. DISPOSE IN COMPLIANCE WITH ALL FEDERAL, STATE, PROVINCIAL, AND
LOCAL LAWS AND REGULATIONS.
WASTE FROM RESIDUES / UNUSED PRODUCTS (DILUTED PRODUCT):
THIS PRODUCT, WHEN DILUTED AS STATED ON THIS SDS, IS NOT A HAZARDOUS WASTE
ACCORDING TO FEDERAL REGULATIONS (40 CFR 261.4 (B)(4)). UNDER RCRA, IT IS
THE RESPONSIBILITY OF THE USER OF THE PRODUCT TO DETERMINE, AT THE TIME
OF DISPOSAL, WHETHER THE WASTE SOLUTION MEETS RCRA CRITERIA FOR HAZARDOUS
WASTE. DISPOSE IN COMPLIANCE WITH ALL FEDERAL, STATE, PROVINCIAL, AND
LOCAL LAWS AND REGULATIONS.
RCRA HAZARD CLASS (UNDILUTED PRODUCT): D002 CORROSIVE WASTE
RCRA HAZARD CLASS (DILUTED PRODUCT): NOT REGULATED
CONTAMINATED PACKAGING: DO NOT RE-USE EMPTY CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOT (GROUND) BILL OF LADING DESCRIPTION: NOT REGULATED
IMDG (OCEAN) BILL OF LADING DESCRIPTION: NOT REGULATED
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES AT CAS# LEVEL:
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE FOLLOWING INVENTORIES:
U.S.A. (TSCA), CANADA (DSL).
RIGHT TO KNOW (RTK):
INGREDIENT(S) CAS # MARTK NJRTK PARTK RIRTK
WATER 7732-18-5
COCAMIDOPROPYL BETAINE 61789-40-0
ALCOHOL ETHOXYLATES 68439-46-3
LAURYL DIMETHYL AMINE OXIDE 1643-20-5
DISODIUM METASILICATE 10213-79-3
PENTAHYDRATE
POTASSIUM HYDROXIDE 1310-58-3 X X X X
CERCLA/SARA:
INGREDIENT(S) CAS # WEIGHT % CERCLA/SARA SECTION 302 SECTION
RQ (LBS) TPQ (LBS) 313
POTASSIUM 1310-58-3 >0.1 - <1% 1000
HYDROXIDE
CANADIAN REGULATIONS:
| 16. OTHER INFORMATION | |
NFPA (NATIONAL FIRE PROTECTION ASSOCIATION):
HEALTH 3
FLAMMABILITY 0
INSTABILITY 0
RATING SCALE: (LOW HAZARD) 0 - 4 (EXTREME HAZARD)
DILUTED PRODUCT:
HEALTH 0
FLAMMABILITY 0
INSTABILITY 0
VERSION NUMBER: 2
PREPARATION DATE: 2018-04-03
REASON FOR REVISION: NOT APPLICABLE
PREPARED BY: NAPRAC
ADDITIONAL ADVICE: DOES NOT CONTAIN AN ADDED FRAGRANCE
NOTICE TO READER:
THIS DOCUMENT HAS BEEN PREPARED USING DATA FROM SOURCES CONSIDERED
TECHNICALLY RELIABLE. IT DOES NOT CONSTITUTE A WARRANTY, EXPRESS OR
IMPLIED, AS TO THE ACCURACY OF THE INFORMATION CONTAINED WITHIN. ACTUAL
CONDITIONS OF USE AND HANDLING ARE BEYOND SELLER'S CONTROL. USER IS
RESPONSIBLE TO EVALUATE ALL AVAILABLE INFORMATION WHEN USING PRODUCT FOR
ANY PARTICULAR USE AND TO COMPLY WITH ALL FEDERAL, STATE, PROVINCIAL AND
LOCAL LAWS AND REGULATIONS.