| Common Name: | SIMPLE GREEN VEHICLE WASH |
| Manufacturer: | SUNSHINE MAKERS |
| SDS Revision Date: | 2/21/2018 |
| SDS Format: | No Format Specified |
| Item Number(s): | 45NR21, 45NR22 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
SIMPLE GREEN(R*) VEHICLE WASH
VERSION NO.: 0202001-18A
ISSUE DATE: FEBRUARY 21, 2018
SUPERSEDES DATE: N.A.
OSHA HCS-2012 / GHS
| SECTION 1: IDENTIFICATION |  |
PRODUCT NAME: SIMPLE GREEN(R*) VEHICLE WASH
ADDITIONAL NAMES:
MANUFACTURER'S PART NUMBER: *PLEASE REFER TO SECTION 16
RECOMMENDED USE: VEHICLE WASH CONCENTRATE
RESTRICTIONS ON USE: APPLICATIONS NOT INVOLVING VEHICLE WASHING
COMPANY:
SUNSHINE MAKERS, INC.
15922 PACIFIC COAST HIGHWAY
HUNTINGTON BEACH, CA 92649
USA
TELEPHONE: 800-228-0709 - 562-795-6000 MON - FRI, 8 AM - 5 PM PST
FAX: 562-592-3830
EMAIL: INFO@SIMPLEGREEN.COM
EMERGENCY PHONE:
CHEM-TEL 24-HOUR EMERGENCY SERVICE: 800-255-3924
| SECTION 2: HAZARDS IDENTIFICATION | |
THIS PRODUCT IS CONSIDERED HAZARDOUS (EYE CORROSIVE/IRRITANT - CATEGORY 2B)
BY THE 2012 OSHA HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
OSHA HCS 2012:
LABEL ELEMENTS:
SIGNAL WORD: WARNING
HAZARD SYMBOL(S)/PICTOGRAM(S): NONE REQUIRED
HAZARD STATEMENTS:
H320: CAUSES EYE IRRITATION.
PRECAUTIONARY STATEMENTS:
P264: WASH HANDS THOROUGHLY AFTER HANDLING.
P305 + P351 + P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P337 + P313 - IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
HAZARDS NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN
OTHER INFORMATION: NONE KNOWN
| SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT CAS NUMBER PERCENT RANGE
WATER 7732-18-5 >87%*
SODIUM CHLORIDE 7647-14-5 <10%*
COCAMIDOPROPYL BETAINE 61789-40-0 <5%*
SODIUM C14-16 OLEFIN SULFONATE 68439-57-6 <5%*
SODIUM LAURETH SULFATE 9004-82-4 <5%*
COCAMIDE MIPA 68333-82-4 <1%*
CARNAUBA WAX 8015-86-9 <1%*
ISOTHIAZOLINONE 55965-84-9 <1%*
FRAGRANCE PROPRIETARY <1%*
COLORANT PROPRIETARY <1%*
*SPECIFIC PERCENTAGES OF COMPOSITION ARE BEING WITHHELD AS A TRADE SECRET
| SECTION 4: FIRST-AID MEASURES | |
INHALATION:
NOT EXPECTED TO CAUSE RESPIRATORY IRRITATION. IF ADVERSE EFFECT OCCURS,
MOVE TO FRESH AIR.
SKIN CONTACT:
NOT EXPECTED TO CAUSE SKIN IRRITATION. IF ADVERSE EFFECT OCCURS, RINSE SKIN
WITH WATER.
EYE CONTACT: CAUSES EYE IRRITATION.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
MAY CAUSE UPSET STOMACH. DRINK PLENTY OF WATER TO DILUTE. SEE SECTION 11.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED: NONE KNOWN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NECESSARY: TREAT SYMPTOMATICALLY
| SECTION 5: FIRE-FIGHTING MEASURES | |
SUITABLE & UNSUITABLE EXTINGUISHING MEDIA:
USE DRY CHEMICAL, CO2, WATER SPRAY OR "ALCOHOL" FOAM. AVOID HIGH VOLUME JET
WATER.
SPECIFIC HAZARDS ARISING FROM CHEMICAL:
IN EVENT OF FIRE, FIRE CREATED CARBON OXIDES MAY BE FORMED.
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS; WEAR FULL
PROTECTIVE CLOTHING. THIS PRODUCT IS NON-FLAMMABLE. SEE SECTION 9 FOR
PHYSICAL PROPERTIES.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY AND EMERGENCY PERSONNEL:
SEE SECTION 8 - PERSONAL PROTECTION. AVOID EYE CONTACT. WEAR SAFETY
GOGGLES.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW INTO OPEN WATERWAYS AND GROUND WATER SYSTEMS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEAN UP:
DIKE OR SOAK UP WITH INERT ABSORBENT MATERIAL. SEE SECTION 13 FOR DISPOSAL
CONSIDERATIONS.
| SECTION 7: HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
ENSURE ADEQUATE VENTILATION. KEEP OUT OF REACH OF CHILDREN. KEEP AWAY FROM
HEAT, SPARKS, OPEN FLAME AND DIRECT SUNLIGHT. DO NOT PIERCE ANY PART OF THE
CONTAINER. DO NOT MIX OR CONTAMINATE WITH ANY OTHER CHEMICAL. DO NOT EAT,
DRINK OR SMOKE WHILE USING THIS PRODUCT.
CONDITIONS FOR SAFE STORAGE INCLUDING INCOMPATIBILITIES:
KEEP CONTAINER TIGHTLY CLOSED. KEEP IN COOL DRY AREA. AVOID PROLONGED
EXPOSURE TO SUNLIGHT. DO NOT STORE AT TEMPERATURES ABOVE 109 DEG. F
(42.7 DEG. C). IF SEPARATION OCCURS, MIX THE PRODUCT FOR RECONSTITUTION.
| SECTION 8: EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE LIMIT VALUES:
NO COMPONENTS LISTED WITH TWA OR STEL VALUES UNDER OSHA OR ACGIH.
APPROPRIATE ENGINEERING CONTROLS:
SHOWERS, EYEWASH STATIONS, VENTILATION SYSTEMS
INDIVIDUAL PROTECTION MEASURES / PERSONAL PROTECTIVE EQUIPMENT (PPE):
EYE CONTACT:
USE PROTECTIVE GLASSES OR SAFETY GOGGLES IF SPLASHING OR SPRAY-BACK IS
LIKELY.
RESPIRATORY:
USE IN WELL VENTILATED AREAS OR LOCAL EXHAUST VENTILATIONS WHEN CLEANING
SMALL SPACES.
SKIN CONTACT:
USE PROTECTIVE GLOVES (ANY MATERIAL) WHEN USED FOR PROLONGED PERIODS OR
DERMALLY SENSITIVE.
GENERAL HYGIENE CONSIDERATIONS:
WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR DRINKING.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: GREEN LIQUID
ODOR: ADDED CHAMOMILE ODOR
ODOR THRESHOLD: NOT DETERMINED
PH: 7.0 - 8.5
FREEZING POINT: 0-3.33 DEG. C (32-38 DEG. F)
BOILING POINT & RANGE: 101 DEG. C (213.8 DEG. F)
FLASH POINT: >212 DEG. F
EVAPORATION RATE: NOT DETERMINED
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS: NOT APPLICABLE
VAPOR PRESSURE: NOT DETERMINED
VAPOR DENSITY: NOT DETERMINED
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT DETERMINED
AUTOIGNITION TEMPERATURE: NON-FLAMMABLE
DECOMPOSITION TEMPERATURE: 109 DEG. F
VISCOSITY: 500-600 CPS
SPECIFIC GRAVITY: 1.01 - 1.03
VOCS: **WATER & FRAGRANCE EXEMPTION IN CALCULATION
SCAQMD 304-91 / EPA 24: NOT TESTED
CARB METHOD 310**:
0.25 G/L
0.002 LB/GAL
0.025%
SCAQMD METHOD 313: NOT TESTED
VOC COMPOSITE PARTIAL PRESSURE: NOT DETERMINED
RELATIVE DENSITY: 1.02 - 1.04
SOLUBILITY: 100% IN WATER
| SECTION 10: STABILITY AND REACTIVITY | |
REACTIVITY: NON-REACTIVE.
CHEMICAL STABILITY:
STABLE UNDER NORMAL CONDITIONS 70 DEG. F (21 DEG. C) AND 14.7 PSIG
(760 MMHg).
POSSIBILITY OF HAZARDOUS REACTIONS: NONE KNOWN.
CONDITIONS TO AVOID: EXCESSIVE HEAT OR COLD.
INCOMPATIBLE MATERIALS:
DO NOT MIX WITH OXIDIZERS, ACIDS, BATHROOM CLEANERS, OR DISINFECTING
AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: NORMAL PRODUCTS OF COMBUSTION - CO, CO2.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
LIKELY ROUTES OF EXPOSURE:
INHALATION: OVEREXPOSURE MAY CAUSE HEADACHE.
SKIN CONTACT:
NOT EXPECTED TO CAUSE IRRITATION, REPEATED CONTACT MAY CAUSE DRY SKIN.
EYE CONTACT: CAUSES EYE IRRITATION.
INGESTION: MAY CAUSE UPSET STOMACH.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS: NO SYMPTOMS EXPECTED UNDER TYPICAL USE CONDITIONS.
DELAYED AND IMMEDIATE EFFECTS AND OR CHRONIC EFFECTS FROM SHORT TERM
EXPOSURE: NO SYMPTOMS EXPECTED UNDER TYPICAL USE CONDITIONS.
DELAYED AND IMMEDIATE EFFECTS AND OR CHRONIC EFFECTS FROM LONG TERM
EXPOSURE: HEADACHE, DRY SKIN, OR SKIN IRRITATION MAY OCCUR.
INTERACTIVE EFFECTS: NOT KNOWN.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY:
ORAL LD50 (RAT): >5 G/KG BODY WEIGHT
DERMAL LD50 (RABBIT): >5 G/KG BODY WEIGHT
CALCULATED VIA OSHA HCS 2012 / GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION
AND LABELING OF CHEMICALS
SKIN CORROSION/IRRITATION:
NON-IRRITANT PER DERMAL IRRITECTION(R*) ASSAY MODELING. NO ANIMAL TESTING
PERFORMED.
EYE DAMAGE/IRRITATION:
IRRITANT PER OCULAR IRRITECTION(R*) ASSAY MODELING. NO ANIMAL TESTING
PERFORMED.
GERM CELL MUTAGENICITY: MIXTURE DOES NOT CLASSIFY UNDER THIS CATEGORY.
CARCINOGENICITY: MIXTURE DOES NOT CLASSIFY UNDER THIS CATEGORY.
REPRODUCTIVE TOXICITY: MIXTURE DOES NOT CLASSIFY UNDER THIS CATEGORY.
STOT-SINGLE EXPOSURE: MIXTURE DOES NOT CLASSIFY UNDER THIS CATEGORY.
STOT-REPEATED EXPOSURE: MIXTURE DOES NOT CLASSIFY UNDER THIS CATEGORY.
ASPIRATION HAZARD: MIXTURE DOES NOT CLASSIFY UNDER THIS CATEGORY.
| SECTION 12: ECOLOGICAL INFORMATION | |
ECOTOXICITY:
VOLUME OF INGREDIENTS USED DOES NOT TRIGGER TOXICITY CLASSIFICATIONS
UNDER THE GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF
CHEMICALS.
AQUATIC: NOT TESTED ON FINISHED FORMULATION.
TERRESTRIAL: NOT TESTED ON FINISHED FORMULATION.
PERSISTENCE AND DEGRADABILITY: READILY BIODEGRADABLE PER OECD 301D
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS: NO DATA AVAILABLE.
| SECTION 13: DISPOSAL CONSIDERATIONS | |
UNUSED OR USED LIQUID:
MAY BE CONSIDERED HAZARDOUS IN YOUR AREA DEPENDING ON USAGE AND TONNAGE
OF DISPOSAL - CHECK WITH LOCAL, REGIONAL, AND OR NATIONAL REGULATIONS FOR
APPROPRIATE METHODS OF DISPOSAL.
EMPTY CONTAINERS: DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS.
NEVER DISPOSE OF USED DEGREASING RINSATES INTO LAKES, STREAMS, AND OPEN
BODIES OF WATER OR STORM DRAINS.
| SECTION 14: TRANSPORT INFORMATION | |
U.N. NUMBER: NOT APPLICABLE
U.N. PROPER SHIPPING NAME: CLEANING COMPOUND, LIQUID NOI
TRANSPORT HAZARD CLASS(ES): NOT APPLICABLE
PACKING GROUP: NOT APPLICABLE
ENVIRONMENTAL HAZARDS: MARINE POLLUTANT - NO
TRANSPORT IN BULK (ACCORDING TO ANNEX II OF MARPOL 73/78 AND IBC CODE):
UNKNOWN.
SPECIAL PRECAUTIONS WHICH USER NEEDS TO BE AWARE OF/COMPLY WITH, IN
CONNECTION WITH TRANSPORT OR CONVEYANCE EITHER WITHIN OR OUTSIDE THEIR
PREMISES: NONE KNOWN.
U.S. (DOT) / CANADIAN TDG: NOT REGULATED FOR SHIPPING.
ICAO/ IATA: NOT CLASSIFIED AS HAZARDOUS
IMO / IMDG: NOT CLASSIFIED AS HAZARDOUS
ADR/RID: NOT CLASSIFIED AS HAZARDOUS
| SECTION 15: REGULATORY INFORMATION | |
| SECTION 16: OTHER INFORMATION | |
SIZE UPC
1 GALLON 043318001567
5 GALLON 043318001574
55 GALLON 043318001581
USA ITEMS LISTED ONLY. NOT ALL ITEMS LISTED. USA ITEMS MAY NOT BE VALID FOR
INTERNATIONAL SALE.
NFPA:
HEALTH 1 - EYE IRRITANT
FLAMMABILITY 0 - NON-FLAMMABLE
STABILITY 0 - STABLE
SPECIAL 0 - NONE
ACRONYMS:
NTP: NATIONAL TOXICOLOGY PROGRAM
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
CPSC: CONSUMER PRODUCT SAFETY COMMISSION
TSCA: TOXIC SUBSTANCES CONTROL ACT
DSL: DOMESTIC SUBSTANCES LIST
PREPARED / REVISED BY: SUNSHINE MAKERS, INC., REGULATORY DEPARTMENT.
THIS SDS HAS BEEN REVISED IN THE FOLLOWING SECTIONS: SDS CREATED
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS GUIDANCE FOR SAFE HANDLING, USE,
PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT TO BE
CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION RELATES
ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR SUCH
MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY PROCESS,
UNLESS SPECIFIED IN THE TEXT.